Renault Trafic 3 (2014-on) Torque Spec Settings

EurovisionNim, CC BY-SA 4.0, via Wikimedia Commons

Below you'll find the tightening torques for the Renault Trafic 3 in both Nm and ft/lbs. The first table contains the most-used torque settings. The tables after it contain all torque spec values I could find.

Most-used torque specs for Renault Trafic 3

Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Oil pan Drain plug 50 37
unverified source
Disc brake Front brake caliper bolts 35 26
unverified source
Disc brake Rear brake caliper bolts 29 21
unverified source

Are these torque settings right for you?

  • Production years: 2014 - present
  • Generation: 3
  • Model variant: Base
  • Also known as: Fiat Talento Mitsubishi Express Nissan NV300 Nissan Primastar Opel Vivaro Vauxhall Vivaro

All Torque Settings in Tables

engine torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Oil pan Drain plug 50 37
unverified source
Oil pan Sump lower cover bolts 12 9
unverified source
Oil filter Oil filter unit bolts 10 7
unverified source
Oil filter Oil filter cover 25 18
unverified source
Oil pressure switch Oil pressure sensor 35 26
unverified source
Oil pump Oil pump bolts 25 18
unverified source
Vacuum pump Vacuum pump bolt 25 18
unverified source
Piston rods Con rod bolt 25 18
unverified source
Cylinder head Cylinder head bolt 30 22
unverified source
Cylinder head Cylinder head cover bolt 12 9
unverified source
Glow plugs Heater plug 14 10
unverified source
Engine block Cylinder block base plate bolts 25 18
unverified source
Engine mounts Right-hand suspended engine mounting bolts 62 46
unverified source
Sensor Coolant temperature sensor 30 22
unverified source
Sensor Crankshaft position sensor bolt 10 7
unverified source
Sensor Oil level sensor 10 7
unverified source
Alternator Alternator bolts 25 18
unverified source
Alternator Positive terminal nut to Alternator 21 15
unverified source
Starter Starter bolts 44 32
unverified source
Starter Starter positive terminal nut 8 6
unverified source
Starter Starter excitation terminal nut 5 4
unverified source
Battery Battery positive terminal wiring nut 8 6
unverified source
Battery Battery negative terminal wiring nut 8 6
unverified source
Battery Battery tray bolts 21 15
unverified source
Camshaft Camshaft bearing cap bolt 10 7
unverified source
Camshaft High pressure pump drive camshaft pulley bolt 30 22
unverified source
Camshaft Exhaust camshaft pulley bolt 10 7
unverified source
Camshaft Inlet camshaft pulley bolt 20 15
unverified source
Crankshaft Crankshaft bearing cap bolts 20 15
unverified source
Crankshaft Crankshaft seal to Gearbox end bolts 12 9
unverified source
Crankshaft Crankshaft accessories pulley bolts 50 37
unverified source
Common rail Injector rail bolts 25 18
unverified source
Common rail Rail pressure sensor 130 96
unverified source
Water pump Water pump bolt 10 7
unverified source
Water pump Additional coolant pump unit support bolt 21 15
unverified source
Water pump Water pump pulley bolt 10 7 Minimum torque
unverified source
Water pump Water pump pulley bolt 20 15 Maximum torque
unverified source
Heater core Thermoplunger unit support nut 44 32
unverified source
Air conditioning Compressor bolt 25 18
unverified source
Air conditioning Intermediate pipe to Compressor connecting pipe bolt 8 6
unverified source
Air conditioning Condenser to Compressor connecting pipe bolt 8 6
unverified source
Air conditioning Condenser to Expansion valve connecting pipe bolt 8 6
unverified source
Air conditioning Rear intermediate to Expansion valve pipe connecting pipe bolt 8 6
unverified source
Air conditioning Expansion valve to Intermediate pipe connecting pipe (Expansion valve outlet) bolt 8 6
unverified source
Belt tensioner/Timing chains Timing cover bolt 15 11
unverified source
Belt tensioner/Timing chains Timing chain guide bolt 25 18
unverified source
Belt tensioner/Timing chains Timing hydraulic tensioner bolts 10 7
unverified source
Belt tensioner/Timing chains Accessories belt tensioning roller bolts 25 18
unverified source
Fuel system High pressure pump bolts 25 18
unverified source
Fuel system High pressure pump pinion nut 90 66
unverified source
Fuel system High pressure pipe nut (High pressure pump end) 27 20
unverified source
Fuel system High pressure pipe nut (Injector end) 27 20
unverified source
Fuel system High pressure pipe between rail and injector nut (Rail end) 24 18
unverified source
Fuel system Injector clamp bolt 7 5
unverified source

drivetrain torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Wheel hub assembly Front wheel hub bolts 105 77
unverified source
Wheel hub assembly Front wheel hub nut 280 207
unverified source
Clutch pressure plate Clutch pressure plate bolts 25 18
unverified source
Clutch assembly Clutch slave cylinder bolts 25 18
unverified source
Flywheel/Flex plate Flywheel bolts 50 37
unverified source
Drive/Axle shaft Rear panhard bar bolt 105 77
unverified source
Drive/Axle shaft Rear panhard bar support bolts 62 46
unverified source

steering torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Tie rod end Acoustic tie rod 62 46
unverified source
Tie rod end Acoustic tie rod to Support battery bolt 21 15
unverified source
Tie rod end Upper engine tie-bar mounting bolt 115 85
unverified source
Tie rod end Lower engine tie-bar mounting bolts 62 46
unverified source
Tie rod end Track rod end nut 37 27
unverified source
Steering column Steering column nuts 21 15
unverified source
Steering shaft Intermediate shaft nut on steering column side 21 15
unverified source
Steering wheel Steering wheel bolt 44 32
unverified source
Power steering Power-assisted steering pump assembly bolt 21 15
unverified source
Power steering Power-assisted steering pipes bolts 12 9
unverified source

exhaust torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Exhaust manifold Exhaust manifold studs 9 7
unverified source
Exhaust manifold Exhaust manifold nuts 15 11 Initial torque
unverified source
Exhaust manifold Exhaust manifold nuts 30 22
unverified source
Exhaust manifold Exhaust gas pressure take-off pipe 14 10
unverified source
Turbo Turbocharger nuts 15 11 Initial torque
unverified source
Turbo Turbocharger nuts 25 18
unverified source
Turbo Turbocharger oil return pipe bolt 10 7
unverified source
Turbo Turbocharger upper oil return pipe bolts 10 7
unverified source
Turbo Turbocharger oil supply pipe bolt (Cylinder block end) 16 12
unverified source
Turbo Turbocharger oil supply pipe bolt (Turbocharger end) 16 12
unverified source
Turbo Turbocharger studs 25 18
unverified source
Turbo Turbocharger nuts 15 11 Initial torque
unverified source
Turbo Turbocharger nuts 25 18
unverified source
EGR Exhaust gas recirculation low pressure assembly bracket bolts 25 18
unverified source
EGR Exhaust gas recirculation low pressure solenoid valve bolts 25 18
unverified source
EGR Exhaust gas cooler nuts 25 18
unverified source
EGR Exhaust gas cooler bolt 25 18
unverified source
EGR Exhaust gas cooler outlet temperature sensor 32 24
unverified source
Diesel particulate filter Particle filter nuts (Turbocharger end) 25 18
unverified source
Diesel particulate filter Particle filter bracket bolts 25 18
unverified source
Diesel particulate filter Particle filter bracket nuts 25 18
unverified source
Diesel particulate filter Temperature sensor particle filter 32 24
unverified source

brakes torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Disc brake Front brake caliper bolts 35 26
unverified source
Disc brake Rear brake caliper bolts 29 21
unverified source
Disc brake Front brake caliper bleed screw 10 7
unverified source
Disc brake Rear brake caliper bleed screw 10 7
unverified source
Disc brake Front brake caliper mounting bolts 105 77
unverified source
Disc brake Rear brake caliper mounting bolts 180 133
unverified source
Disc brake Front brake disc bolt 21 15
unverified source
Brake line Front brake hose 17 13
unverified source
Brake line Rear brake hose 17 13
unverified source
Brake line Rear brake pipe unions 17 13
unverified source
Brake pedal Brake pedal bolt and nuts 21 15
unverified source
Brake pedal Accelerator pedal bolts 8 6
unverified source
Brake pedal Clutch pedal nuts 21 15
unverified source
Master cylinder Clutch master cylinder bolts 21 15
unverified source
Parking brake Parking brake lever bolt 44 32
unverified source
Parking brake Parking brake secondary cable support bolt 21 15
unverified source
ABS Hydraulic unit bolts 8 6
unverified source
ABS Hydraulic unit support mounting bolts 8 6
unverified source
ABS Hydraulic unit inlet pipes 14 10
unverified source
ABS Hydraulic unit outlet pipes 14 10
unverified source

suspension torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to
Struts Front strut subframe mounting bolt 105 77
unverified source
Shock absorbers/shocks Front shock absorber nuts 180 133
unverified source
Shock absorbers/shocks Rear shock absorber nut 180 133
unverified source
Stabilizer bar Front anti-roll bar tie rod nuts 44 32
unverified source
Stabilizer bar Front anti-roll bar clamp bolts 21 15
unverified source
Control arm Front driveshaft lower arm bolts 125 92
unverified source
Ball joint Front lower ball joint nut 105 77
unverified source
Ball joint Axial ball joint linkage 50 37
unverified source
Ball joint Universal joint nut 21 15
unverified source

general torque settings

Save to email ✉️
Part Description Torque (Nm) Torque (ft/lbs) Remarks Applies to

Did you find the answer to your specific question?
👍 4 👎 26

Related Vans: