Citroën Relay 3 (2006-on) Torque Spec Settings

Rudolf Stricker, CC BY-SA 3.0, via Wikimedia Commons
Below you'll find the tightening torques for the Citroën Relay 3 in both Nm and ft/lbs. The first table contains the most-used torque settings. The second table contains all torque spec values I could find.
Most-Used Torque Settings for Relay 3
Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Source |
---|---|---|---|---|---|
Front brake caliper bolts | 34 | 25 |
![]() |
||
Rear brake caliper bolts | 30 | 22 |
![]() |
To make sure these are the correct tightening torque values, you can use the data below to verify this is the right model.
Are these torque settings right for you?
- Production years: 2006 - present
- Generation: 3
- Model variant: Base
- Also known as:
All Torque Settings in Tables
General torque settings
Nut | Torque (Nm) | Torque (ft/lbs) | Remarks | Source |
---|---|---|---|---|
Road wheels | 160 | 118 | Steel rims, 15 inch wheels |
![]() |
Road wheels | 180 | 133 | Steel rims, 16 inch wheels |
![]() |
Road wheels | 160 | 118 | Aluminium rims, 15 inch wheels |
![]() |
Road wheels | 180 | 133 | Aluminium rims, 16 inch wheels |
![]() |
Drain cap | 50 | 37 | F30 DT engine |
![]() |
Cylinder block sump | 25 | 18 | F30 DT engine |
![]() |
Oil pressure sensor | 40 | 30 | F30 DT engine |
![]() |
Oil level/Oil temperature sensor | 25 | 18 | F30 DT engine |
![]() |
Cylinder head screws | 130 | 96 | F30 DT engine, 15mm screws |
![]() |
Cylinder head screws | 65 | 48 | F30 DT engine, 12mm screws |
![]() |
Cylinder head screws | 25 | 18 | F30 DT engine, 8mm screws |
![]() |
Air inlet manifold | 30 | 22 | F30 DT engine |
![]() |
Exhaust manifold | 25 | 18 | F30 DT engine |
![]() |
Clutch pressure plate to Flywheel | 20 | 15 |
![]() |
|
Camshaft carrier bearings bolt | 25 | 18 | F30 DT engine |
![]() |
Camshaft sprockets | 110 | 81 | F30 DT engine |
![]() |
Front brake disc bolts | 12 | 9 |
![]() |
|
Front brake caliper bolts | 34 | 25 |
![]() |
|
Front brake caliper support bolts | 210 | 155 |
![]() |
|
Rear brake caliper bolts | 30 | 22 |
![]() |
|
Rear brake caliper yoke bolts | 160 | 118 |
![]() |
|
Rear brake disc bolts | 12 | 9 |
![]() |
|
Suspension arm to Front subframe horizontal bolt | 320 | 236 | Front suspension |
![]() |
Suspension arm to Front subframe vertical bolt | 320 | 236 | Front suspension |
![]() |
Hub carrier ball joint to Suspension arm | 150 | 111 | Front suspension |
![]() |
Steering ball joint to Front hub carrier nut | 80 | 59 | Front suspension |
![]() |
Front hub carrier ball joint bolts | 115 | 85 | Front suspension |
![]() |
Front strut to Body fixing bolts | 60 | 44 |
![]() |
|
Conrod screws | 50 | 37 | F30 DT engine, Pre-tighten |
![]() |
Power-assisted steering pump bolts | 22 | 16 | PUMA engine |
![]() |
Power-assisted steering pump bolts | 40 | 30 | SOFIM engine |
![]() |
Hub nut | 150 | 111 | Front suspension |
![]() |
Hub nut | 450 | 332 | Rear suspension |
![]() |
Coolant pump | 50 | 37 | F30 DT engine, 10mm screws |
![]() |
Coolant pump | 25 | 18 | F30 DT engine, 8mm screws |
![]() |
Power steering pump drive gear bolt | 130 | 96 | F30 DT engine |
![]() |
Anti-roll bar bearing fixing on front subframe | 50 | 37 | Front suspension |
![]() |
Anti-roll bar bearing bolts | 190 | 140 | Rear suspension, with metallic suspension |
![]() |
Anti-roll bar bearing bolts | 45 | 33 | Rear suspension, with pneumatic suspension |
![]() |
Anti-roll bar rod nuts | 30 | 22 | Rear suspension, with metallic suspension |
![]() |
Anti-roll bar rod nuts | 30 | 22 | Rear suspension, with pneumatic suspension |
![]() |
Anti-roll bar transfer bar nut | 56 | 41 | Front suspension |
![]() |
Did you find the answer to your specific question?
👍 2 👎 5