Toyota 4Runner 5 (2010-on) Torque Spec Settings
By Kevauto - Own work, CC BY-SA 4.0
Below you'll find the tightening torques for the Toyota 4Runner 5 in both Nm and ft/lbs. The first table contains the most-used torque settings. The tables after it contain all torque spec values I could find.
Most-used torque specs for Toyota 4Runner 5
| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to |
|---|
To make sure these are the correct tightening torque values, you can use the data below to verify this is the right model.
Are these torque settings right for you?
- Production years: 2010 - present
- Generation: 5
- Type of van: car
- Model variant: Base
All Torque Settings in Tables
engine torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to | |
|---|---|---|---|---|---|---|
| Oil pan | Oil pan drain plug to No.2 oil pan | 38 | 28 |
|
|
|
| Oil pan | Oil pan to Cylinder block and Timing chain cover | 26 | 19 |
|
|
|
| Oil pan | Oil pan stud bolt | 8 | 6 | Stud bolt A |
|
|
| Oil pan | Oil pan stud bolt | 3 | 2 | Stud bolt B |
|
|
| Oil pan | No.2 oil pan to Oil pan | 9 | 7 |
|
|
|
| Oil filter | Oil filter to Oil filter bracket | 17 | 13 |
|
|
|
| Oil filter | Oil filter bracket union to Cylinder block | 25 | 18 |
|
|
|
| Oil filter | Oil filter bracket to Screw plug | 49 | 36 |
|
|
|
| Oil filter | Oil filter bracket to Cylinder block | 25 | 18 |
|
|
|
| Oil filter | Oil filter union to Oil filter bracket | 43 | 32 |
|
|
|
| Oil filter | Oil strainer to Oil pan | 26 | 19 |
|
|
|
| Oil pressure switch | Oil pressure switch to Cylinder block | 15 | 11 |
|
|
|
| Oil dipstick | Engine oil level dipstick guide to Front No.1 engine mounting bracket | 20 | 15 |
|
|
|
| Oil pump | Oil pump relief valve plug to Timing chain cover | 49 | 36 |
|
|
|
| Oil pump | Oil pump cover to Timing chain cover | 9 | 7 |
|
|
|
| Piston rods | Connecting rod cap to Connecting rod | 25 | 18 | Step 1 |
|
|
| Cylinder head | Cylinder head to Cylinder block | 39 | 29 |
|
|
|
| Cylinder head | Cylinder head stud bolt | 3 | 2 | Stud bolt A |
|
|
| Cylinder head | Cylinder head stud bolt | 8 | 6 | Stud bolt B |
|
|
| Cylinder head | Cylinder head stud bolt | 8 | 6 | Stud bolt C |
|
|
| Cylinder head | No.1 head straight screw plug to Cylinder head | 44 | 32 |
|
|
|
| Cylinder head | No.2 head straight screw plug to Cylinder head | 140 | 103 |
|
|
|
| Cylinder head | No.1 engine hanger to Cylinder head | 42 | 31 |
|
|
|
| Cylinder head | Cylinder head cover to Cylinder head and Timing chain cover | 9 | 7 |
|
|
|
| Spark plugs | Spark plug to Cylinder head | 18 | 13 |
|
|
|
| Intake manifold | Intake manifold to Cylinder head | 25 | 18 |
|
|
|
| Intake manifold | Purge VSV to Intake manifold | 9 | 7 |
|
|
|
| Intake manifold | Wiring harness clamp bracket to Intake manifold | 8 | 6 |
|
|
|
| Intake manifold | Air cleaner cap hose clamp | 5 | 4 |
|
|
|
| Intake manifold | Air cleaner case to Body | 12 | 9 |
|
|
|
| Throttle body | Throttle body with motor assembly to Intake manifold | 9 | 7 |
|
|
|
| Engine block | Cylinder block water drain cock to Cylinder block | 25 | 18 |
|
|
|
| Engine block | Cylinder block drain cock plug to Cylinder block drain cock | 13 | 10 |
|
|
|
| Engine block | PCV valve to Cylinder head cover | 5 | 4 |
|
|
|
| Engine block | Oil seal retainer to Cylinder block | 13 | 10 |
|
|
|
| Engine block | No.1 chain vibration damper to Cylinder block and cylinder head bolt | 21 | 15 |
|
|
|
| Engine block | No.1 chain vibration damper to Cylinder block and cylinder head nut | 18 | 13 |
|
|
|
| Engine block | No.1 oil nozzle to Cylinder block | 7 | 5 |
|
|
|
| Engine block | No.1 chain tensioner to Cylinder block | 10 | 7 |
|
|
|
| Engine mounts | Front No.1 engine mounting bracket RH to Cylinder block | 51 | 38 |
|
|
|
| Engine mounts | Front No.1 engine mounting bracket LH to Cylinder block | 51 | 38 |
|
|
|
| Engine mounts | Front engine mounting insulator to Front No.1 engine mounting bracket | 46 | 34 |
|
|
|
| Engine mounts | Front engine mounting insulator LH to Harness bracket | 13 | 10 |
|
|
|
| Engine mounts | Engine mounting insulator to Body | 40 | 30 |
|
|
|
| Engine mounts | Rear engine mounting heat insulator to Rear no.1 engine mounting insulator | 12 | 9 |
|
|
|
| Engine mounts | Rear No.1 engine mounting insulator to Transmission | 65 | 48 |
|
|
|
| Engine mounts | No.3 frame crossmember to Rear no.1 engine mounting insulator | 30 | 22 |
|
|
|
| Engine mounts | Rear engine under cover to Body | 29 | 21 |
|
|
|
| Engine mounts | No.1 engine under cover to Body | 29 | 21 |
|
|
|
| Engine mounts | Engine under cover seal to Rear engine under cover | 29 | 21 |
|
|
|
| Sensor | Accelerator pedal position sensor assembly to Body | 5 | 4 |
|
|
|
| Sensor | Camshaft position sensor to Timing chain cover | 9 | 7 |
|
|
|
| Sensor | Crankshaft position sensor to Timing chain cover | 9 | 7 |
|
|
|
| Sensor | Engine coolant temperature sensor to Cylinder block | 20 | 15 |
|
|
|
| Sensor | Knock sensor to Cylinder block | 20 | 15 |
|
|
|
| Sensor | Air fuel ratio sensor to Front exhaust pipe assembly | 44 | 32 |
|
|
|
| Sensor | Air fuel ratio sensor to Front exhaust pipe assembly | 40 | 30 | For use with SST |
|
|
| Sensor | Heated oxygen sensor to Front exhaust pipe assembly | 44 | 32 |
|
|
|
| Sensor | Heated oxygen sensor to Front exhaust pipe assembly | 40 | 30 | For use with SST |
|
|
| Sensor | Manifold absolute pressure sensor to Intake air connector | 5 | 4 |
|
|
|
| Alternator | Retainer plate to Generator drive end frame assembly | 2 | 1 |
|
|
|
| Alternator | Generator coil to Generator drive end frame assembly | 6 | 4 |
|
|
|
| Alternator | Generator brush holder assembly to Generator coil | 2 | 1 |
|
|
|
| Alternator | Generator rear end cover to Generator coil | 5 | 4 |
|
|
|
| Alternator | Generator with clutch pulley to Generator rotor assembly | 111 | 82 |
|
|
|
| Alternator | Generator with clutch pulley to Generator rotor assembly | 88 | 65 | For use with SST |
|
|
| Alternator | Generator assembly to Timing chain cover | 43 | 32 |
|
|
|
| Alternator | Generator assembly to Generator wire | 10 | 7 |
|
|
|
| Starter | Starter assembly to Transmission housing | 37 | 27 |
|
|
|
| Starter | Starter drive housing assembly to Magnet starter switch assembly | 6 | 4 |
|
|
|
| Starter | Commutator end frame to Brush holder assembly | 2 | 1 |
|
|
|
| Starter | Commutator end frame to Starter drive housing assembly | 6 | 4 |
|
|
|
| Starter | Starter wire | 10 | 7 |
|
|
|
| Starter | Lead wire to Terminal C | 6 | 4 |
|
|
|
| Battery | Ignition coil to Cylinder head cover | 9 | 7 |
|
|
|
| Camshaft | Camshaft timing gear to Camshaft | 78 | 58 |
|
|
|
| Camshaft | Camshaft timing sprocket to No.2 camshaft | 78 | 58 |
|
|
|
| Camshaft | Timing chain guide to No.1 camshaft bearing cap | 10 | 7 |
|
|
|
| Camshaft | Camshaft bearing cap to Cylinder head bolt | 12 | 9 | Bolt A |
|
|
| Camshaft | Camshaft bearing cap to Cylinder head bolt | 16 | 12 | Bolt B |
|
|
| Camshaft | Camshaft timing oil control valve to Cylinder head | 8 | 6 |
|
|
|
| Crankshaft | Crankshaft pulley to Crankshaft | 260 | 192 |
|
|
|
| Crankshaft | Drive plate and ring gear to Crankshaft | 74 | 55 |
|
|
|
| Crankshaft | Balance shaft drive gear to No.1 balance shaft | 25 | 18 |
|
|
|
| Crankshaft | No.1 balance shaft drive gear to No.1 balance shaft | 36 | 27 |
|
|
|
| Crankshaft | No.2 balance shaft drive gear to No.2 balance shaft | 36 | 27 |
|
|
|
| Crankshaft | No.1 balance shaft to Cylinder block | 18 | 13 |
|
|
|
| Crankshaft | No.2 balance shaft to Cylinder block | 18 | 13 |
|
|
|
| Crankshaft | Crankshaft cylinder block | 39 | 29 | Step 1 |
|
|
| Water pump | Water pump assembly to Timing chain cover bolt | 26 | 19 | For bolt A |
|
|
| Water pump | Water pump assembly to Timing chain cover bolt | 9 | 7 | For bolt B |
|
|
| Radiator | Radiator assembly to Vehicle body | 18 | 13 |
|
|
|
| Radiator | Fan shroud to Radiator assembly | 5 | 4 |
|
|
|
| Radiator | Radiator reservoir to Fan shroud | 5 | 4 |
|
|
|
| Radiator | Fluid coupling and fan pulley to Water pump assembly | 25 | 18 |
|
|
|
| Radiator | Fluid coupling to Fan | 5 | 4 |
|
|
|
| Radiator | Water inlet to Timing chain cover | 28 | 21 |
|
|
|
| Radiator | No.1 water by-pass pipe to Timing chain cover | 18 | 13 |
|
|
|
| Air conditioning | Discharge hose sub-assembly to Cooler compressor assembly | 10 | 7 |
|
|
|
| Air conditioning | Suction hose sub-assembly to Cooler compressor assembly | 10 | 7 |
|
|
|
| Air conditioning | Suction hose sub-assembly to Engine | 8 | 6 |
|
|
|
| Air conditioning | Cooler compressor assembly to Engine | 25 | 18 |
|
|
|
| Air conditioning | No.1 compressor mounting bracket to Timing chain cover and cylinder block bolt | 45 | 33 | Bolt A |
|
|
| Air conditioning | No.1 compressor mounting bracket to Timing chain cover and cylinder block bolt | 45 | 33 | Bolt B |
|
|
| Air conditioning | No.1 compressor mounting bracket to Timing chain cover and cylinder block bolt | 25 | 18 | Bolt C |
|
|
| Air conditioning | Cooler compressor to No.1 compressor mounting bracket | 25 | 18 |
|
|
|
| Belt tensioner/Timing chains | V-ribbed belt tensioner to Timing chain cover and Cylinder block bolt | 40 | 30 | Bolt 1 |
|
|
| Belt tensioner/Timing chains | V-ribbed belt tensioner to Timing chain cover and Cylinder block bolt | 21 | 15 | Bolt 2 |
|
|
| Belt tensioner/Timing chains | No.1 idler pulley to Timing chain cover | 43 | 32 |
|
|
|
| Belt tensioner/Timing chains | Timing chain cover to Cylinder head and cylinder block bolt | 60 | 44 | Bolt A |
|
|
| Belt tensioner/Timing chains | Timing chain cover to Cylinder head and cylinder block bolts and nut | 21 | 15 | Bolts B, D and nut |
|
|
| Belt tensioner/Timing chains | Timing chain cover to Cylinder head and cylinder block bolt | 26 | 19 | Bolt C |
|
|
| Belt tensioner/Timing chains | Timing chain cover to Cylinder head and cylinder block bolt | 21 | 15 | Bolt E |
|
|
| Belt tensioner/Timing chains | Timing chain cover to Cylinder head and cylinder block bolt | 46 | 34 | Bolt F |
|
|
| Belt tensioner/Timing chains | Suction hose to Timing chain cover | 8 | 6 |
|
|
|
| Belt tensioner/Timing chains | Straight screw plug to Timing chain cover | 17 | 13 |
|
|
|
| PCM | ECM to Reinforcement | 8 | 6 |
|
|
|
| PCM | ECM to ECM bracket | 3 | 2 |
|
|
|
| PCM | ECM to No.2 ECM bracket | 3 | 2 |
|
|
|
| Fuel system | Fuel delivery pipe to Cylinder block | 12 | 9 |
|
|
|
| Fuel system | Fuel pressure regulator assembly to Fuel delivery pipe | 9 | 7 |
|
|
|
| Fuel system | Fuel pump ECU to Frame | 31 | 23 |
|
|
|
| Fuel system | Fuel tank band to body | 40 | 30 |
|
|
|
| Fuel system | No.1 fuel tank protector sub-assembly to Body | 20 | 15 |
|
|
|
| Fuel system | No.3 fuel tank protector to Fuel tank | 5 | 4 |
|
|
|
| Fuel system | Fuel pressure pulsation damper assembly to Fuel delivery pipe | 9 | 7 |
|
|
drivetrain torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to |
|---|
steering torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to | |
|---|---|---|---|---|---|---|
| Power steering | Power steering oil pressure switch to Pressure feed tube | 21 | 15 |
|
|
|
| Power steering | Pressure feed tube union bolt | 50 | 37 |
|
|
|
| Power steering | Vane pump assembly set bolt | 21 | 15 |
|
|
|
| Power steering | Vane pump front housing to Vane pump rear housing | 22 | 16 |
|
|
|
| Power steering | Vane pump oil reservoir sub-assembly to Vane pump front housing | 9 | 7 |
|
|
exhaust torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to | |
|---|---|---|---|---|---|---|
| Exhaust manifold | Exhaust manifold to Cylinder head | 36 | 27 |
|
|
|
| Exhaust manifold | Exhaust manifold to Front exhaust pipe assembly | 43 | 32 |
|
|
|
| Exhaust manifold | No.1 exhaust manifold heat insulator to Exhaust manifold | 12 | 9 |
|
|
|
| Exhaust manifold | Manifold stay to Exhaust manifold | 30 | 22 |
|
|
|
| Exhaust manifold | Manifold stay to Transmission bolt | 71 | 52 | Bolt A |
|
|
| Exhaust manifold | Manifold stay to Transmission bolt | 44 | 32 | Bolt B |
|
|
| Exhaust manifold | Front exhaust pipe to Center exhaust pipe | 43 | 32 |
|
|
|
| Exhaust manifold | Center exhaust pipe to Tailpipe assembly | 48 | 35 |
|
|
|
| Exhaust manifold | No.4 intake pipe to Exhaust manifold | 20 | 15 |
|
|
brakes torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to |
|---|
suspension torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to |
|---|
general torque settings
Save to email ✉️| Part | Description | Torque (Nm) | Torque (ft/lbs) | Remarks | Applies to |
|---|
By Mr.choppers - Own work, CC BY-SA 3.0
Did you find the answer to your specific question?
👍 0 👎 0
